Getting ECV in van - how easy is it to remove the batteries?

[Anita123]

There is no way I can lift the ECV into the back of my van. I'm thinking that if we take the batteries off temporarily that would make it a lot lighter.

Does anyone have an experience with removing the batteries? Walker site claims the ECV can be disassembled in 15 seconds but I'm wondering is it really that easy.

Also, do you think without the extra 70 or 80 pounds of battery weight that between myself (not very strong) and a teen we could lift it into the back of a mini van.

I usually have my husband along but he won't be there this time.

 

[Cheshire Figment]

Generally there are two types of ECVs, the smaller travel type and the standard.

For all of them you start by removing the seat by lifting up on it while holding both sides. It may be necessary to wiggle the seat side to side while pulling up.

For the travel scooters there is normally an handle on the battery pack; just pull up on it and the battery pack disconnects.

For full size there may or may not be a shroud over the bottom; if there is, remove it by lifting up. The batteries will have quick release connectors and some sort of handle on them. Disconnect the connectors and lift up each battery individually. Some ECVs may have a strap that hold the batter down while others will not.

On all scooters there is a way to separate the motor/rear wheel assembly from the rest of it; for the ull size you probably will need to do this.

And on all you probably need to lower the tiller.

For a very much more detailed explanation on a full-size, see Post #5 in the disABILITIES FAQs; you can follow the link in my signature to get there.

 

[Debbie-TN]

My cousin and I have taken them apart before. They're not too bad. The heaviest part is supposed to be around 40 pounds. You take off the seat and batteries, then break apart the front and back parts. I just gave this tip on another question, but in case you don't read it, I'll tell it again. Be sure and get some cheap garden or work gloves to help pick up the pieces. It really helps you grip and saves your hands.

 

[peemagg]

Mine as long as I take the seat and battery off, then I can lift the rest of it assembled into our van by myself. I think with those parts taken off it weighs about 60 lbs. I don't do it often, but my Mom (age 65) and I (41) can lift it up into the van intact. Mine only weighs 115 lbs total. The one you are renting may or may not weigh more than that.

Do you know what brand of scooter Walker usually rents, or the one you are renting? This might give us a better idea as to what you are looking at as far as size and how it breaks down. I know mine after I take the seat and battery off it comes apart by just lifting a latch that separates the platform from the rear wheels. The one you rent might be simular.

 

[Anita123]

I'm just renting the smallest scooter that Walker has. I have plenty of room in the back of my van, so the ECV will fit in the back intact. I may have to take the batteries off though if lifting it intact is an issue because it weighs too much.

I reserved one yesterday to be delivered to the resort for my stay. So I'm hoping it will be fine.

Thanks for the responses.